Smelly washer bottle

Technical questions and answers about the Mazda Bongo

Moderators: Doone, westonwarrior

Locked
Steve L
Bongolier
Posts: 188
Joined: Mon May 28, 2007 4:24 pm
Location: Selby, North Yorks

Smelly washer bottle

Post by Steve L » Thu Jul 19, 2007 12:11 pm

Since buying my Bongo the washer bottle stank of stagnant water. I have been meaning to do something about it so yesterday I sorted it and thought I would put what I did in print in case it was use to anyone else with a similar problem.
My vehicle is one with the winter pack, with two batteries fitted from the factory, so the below refers to this model.

Before doing this it may be prudent to disconnect the negative battery lead of the drivers side battery (although I didn't) :roll:

The washer bottle is held on by two bolts on the front of the bodywork, the bottom has a plastic extrusion which locates into the bodywork underneath.
Before I was able to remove the bottle I needed to remove the passenger side battery. I disconnected the battery leads (negative first), then unfastened the battery clamps sufficiently to allow them to be unhooked from underneath the tray.
There is now a session of battery juggling because the bonnet stay is in the way. Its best if you can get someone to hold the bonnet open for you while you lift the battery out, or re position the bonnet stay.
Once the battery is out use a 12mm socket/spanner to remove the four bolts securing the battery tray and once this is out you will need to use a 12mm socket on a long extension to remove the two bolts securing the tray support. The support is attached at the rear to a brake pipe with a plastic clip but you do not need to remove the support just manoeuvre it to one side.
Then undo the two securing bolts of the washer bottle (10mm).
There are two pipes leading to the two pumps on the bottle (one at the front and one at the back) along with two electrical connections (both are different so you cannot mix them up).
On mine the pipes were clipped to the bodywork but the pipes easily pull out of the clip.
The bottle also supports the wiring loom with a cable tie, rather than try to remove the cable tie from the bottle I used a small screwdriver to open the clamp and pulled out the strap.

First disconnect the electrical connections (squeeze at the sides and pull type) then pull the rearmost pipe from its pump. I then put my finger over the pump exit (cos the bottle was full) before pulling the pipe from the from front pump. There is an F and an R stamped into the bottle so you know which pipes to fit on which pump.
Once the bottle was out I gave it a good flush until I was satisfied the smell had gone.
Refitting is a reversal of the above procedure. I then filled it with some ready mixed washer fluid.
This job is probably a lot easier doing it than reading about it, it took me about an hour all in.

Hope this is of some assistance.
1995 N reg 2WD AFT in green/grey
www.whiteroseancestry.co.uk
trekie

Post by trekie » Thu Jul 19, 2007 1:10 pm

if it was that difficult to get at the washer bottle, how did you manage to get near enough with your nose to smell it :?: :?: :lol: :lol:

regards

alex and jan(gone away)
User avatar
mikeonb4c
Supreme Being
Posts: 22877
Joined: Sun Nov 05, 2006 10:49 pm
Location: Living with Mango Bongo in the North West but with a tendency to roam
Contact:

Post by mikeonb4c » Thu Jul 19, 2007 1:50 pm

I'm going to use my Pela pump to suck out the contents, refill with disinfectant solution, suck that out, then refill with screenwash :)

All I need before I can start work is a smelly bottle (thats le not om folks)

8)
dobby
Supreme Being
Posts: 2622
Joined: Fri Feb 04, 2005 8:45 pm

Post by dobby » Thu Jul 19, 2007 3:50 pm

Top tip mikeonb4c!

My Pela pump arrived today - another use for it.

Told mrs Dobby that we could "empty the washing machine with it!" next time it broke down.
Have to justify all gadget costs in our 'ouse
tridentlee

Post by tridentlee » Thu Jul 19, 2007 7:41 pm

WHAT THE HELL IS A PELA PUMP ? IS IT LIKE A BIKE PUMP ? CONFUSED, OH YES
ChrisEm

Post by ChrisEm » Thu Jul 19, 2007 7:44 pm

Its a vacuum pump and tank all in one. Pump the handle to create a vacuum and it enables you to suck out oil or other fluids from confined or awkward places. see here - http://www.pelapumps.co.uk/
Locked

Return to “Techie Stuff”