Bongo Fury

What type of gas is used in the 2002 Era Bongo A/C system, R12 or the more environmentally friendly R134a stuff? I can see a HP port, can you point me as to where to find the LP port. Cheers

Its the R134a gas.

Cancel that, I found the fact sheet. 950g of R134a for front / rear system

Thanks g8dhe, looks like we had a cross posting.

funny story, the lp point is located behind the rads you can access from the left side at the front of the rads and reach down behind (like you are trying to give a reach around to a rather large woman)

anyhoo funny story goes, did an a/c refresh 4 weeks ago and then just over a week ago it was blowing hot, bloody annoying, i located a leak at the pipes leading into the rear heater and changed the o rings on them, that sorted that, a tiny bit of oil came out and i thought "it'll be fine" .... it wasn't
the little bit of oil turned out to be all of it and the system only takes 14ml of PAG 46 ( the low viscosity stuff) so i had a lovely weekend in les vosges mountains near the german border and the aircon was working great untill we were just about to head back, then the squealing started,
As soon as it started i pulled over and did the usual rigmarol of checking the engine and promptly identified the a/c pump as making the horrible pig noise so it was a rather warm 2hour journey home

so yesterday at lunch time i regassed the systeme ,again for third time, and this time got the machine to put the oil in, 40euros for a 500ml bottle and i used 15ml gave the back of the a/c pulley a bit a lube and thankfully i haven't wreaked the pump

When you gas the system make sure you put the oil in too or you'll end up with a pig in your engine bay

Thanks for the extra information. I’ve a mate who is going to do the re gas (at mates rates). Helpful if I can advise him as much as possible.

just remember, reach around, big fat lady for LP and with the left hand, to make it feel strange