Page 1 of 1
Strange starting problem
Posted: Thu May 29, 2008 9:21 am
by andyh
Strange problem - wondered if anyone else had come across this one. Every so often I try to start and get nothing but a click. Everything else works - glowplug light goes off as normal but turning the key does nothing. Try again and it works... My shortlist is
Bad earth on starter
Fault on autobox park position
Bad Earth somewhere else
It doesnt help being intermittment - so before I start stripping it apart I thought I'd ask..... Any ideas?
Re: Strange starting problem
Posted: Thu May 29, 2008 9:27 am
by Nevets
Sounds like the beginnings of a starter motor fault to me
Re: Strange starting problem
Posted: Thu May 29, 2008 9:48 am
by mikeonb4c
Apart from the obvious (poor battery connection - I'm embarrassed to say when I bought mine I'm not 100% certain I didn't condemn a battery and buy a new one without checking the clamps were on tight), it sounds like the start of starter motor solenoid probs. You'll be wanting one of those replacement parts kits mentioned on here but (as usual) can't think where. BF member Moonshine is the original expert on it though, I can remember that much.
Re: Strange starting problem
Posted: Thu May 29, 2008 9:59 am
by brorabongo
Re: Strange starting problem
Posted: Thu May 29, 2008 3:42 pm
by andyh
As always prompt and informative replies... defo sounds like solenoid contacts - have ordered a kit. Thanks guys..
Re: Strange starting problem
Posted: Thu May 29, 2008 8:33 pm
by brorabongo
DON'T FORGET TO LET US KNOW HOW YOU GET ON!!
sorry for shouting.
Re: Strange starting problem
Posted: Wed Jun 04, 2008 1:26 pm
by andyh
brorabongo wrote:DON'T FORGET TO LET US KNOW HOW YOU GET ON!!
sorry for shouting.
Followed instructions (there's even a video on youtube on changing contacts!!) and apart from one skinned knuckle it all went to plan. I only went for the contacts set at £6 on ebay and which meant I had to give the piston a really good clean but it now starts like a dream!!
Re: Strange starting problem
Posted: Wed Jun 04, 2008 1:31 pm
by mikeonb4c
andyh wrote:brorabongo wrote:DON'T FORGET TO LET US KNOW HOW YOU GET ON!!
sorry for shouting.
Followed instructions (there's even a video on youtube on changing contacts!!) and apart from one skinned knuckle it all went to plan. I only went for the contacts set at £6 on ebay and which meant I had to give the piston a really good clean but it now starts like a dream!!
Faaaaantastic. Another stunning result for this club and the ingenuity of its members. Off you go then
Re: Strange starting problem
Posted: Tue Jul 29, 2008 9:30 am
by credible
Here's the video of how to change the solenoid plunger & plates.. easy!
http://www.youtube.com/watch?v=5pnySma88gY
just about to have a go myself!
credible
Re: Strange starting problem
Posted: Tue Jul 29, 2008 6:46 pm
by dipstick
You would have thought the U Tube cameraman could have turned a light on instead of leavin us in the dark, 3 out of 10 for effort I think.
Re: Strange starting problem
Posted: Tue Jul 29, 2008 9:21 pm
by MattK
...........awaiting dipsticks perfectly lit youtube video of how to change Mazda Bongo starter motor solenoid contacts with baited breath and barely restrained anticipation.
Re: Strange starting problem
Posted: Wed Jul 30, 2008 12:10 am
by dipstick
Come on, if you are going to go to the trouble of making a video then at least make it visible, I bet any-one who knows nothing about changing the contacts in a starter motor cannot follow what was happening.