The Bongo is fitted with air conditioning as standard, most have a separate fan, controls & heating/cooling matrix fitted front & rear, a few never had it fitted in the rear, some have had it taken out during conversion and some have been by-passed due to leaks.
Some are fitted with manual type controls, while the rest are fitted with digital climate controls. For both, the rear system needs to be switched on from the front, for the slider type controls the rear heater system has an on/off master switch, situated to the right of the drivers steeing wheel on the main dashboard switch panel. For the Digital climate control, there is a switch on the control panel labelled "Rear" this can be used to control the fan speed & mode in the rear (but not the temperature bizarrely) by holding down the rear button for a few seconds.
The front fan is prone to water ingress, which gets into the motor bearing, either siezing it up completely or causing sufficient friction to increase the current drawn, thus causing damage to the fan resistor packs. It's worth trying to repair these before resorting to the cost of replacing them, many have done so succesfully with the help of the factsheets & forum.
There is a drainage hole in the bottom of the fan casing that can get blocked. This hole is larger on the new replacement part, so it's worth enlarging the hole if you're stripping it down.
If the front fan is blowing ok, but the flaps don't seem to be directing the air to the desired outlets, check the linkages on the inboard side of the drivers footwell, these are prone to breaking or coming adrift.
All this & more is detailed in the links below.
Air conditioning Factsheet click here
Climate Control Unit Illumination Factsheet click here
Fan Speed Resistor Factsheet click here
Front Heater Factsheet click here
Heater Repair Factsheet click here
Bongo Clinic Archives click here
Schematics courtesy of Lushprojects (Info used from Diesel engine manufactured between Nov 97 to Aug 99 there may be some slight differences with your model) click here:
Belts, pulleys & adjusters
Air ducts
Heater components
Heater control 2
Heater control 1
Heater components
Rear heater
Rear heater components
Air conditioning 2
Air conditioning 1
Air conditioning
Air con compressor
Evaporator
Rear air conditioning
Rear cooling channels & vents
Forum discussions past & present, click here:
Air con
Front heater
Heater Fan
Heater controls
Rear heater
Climate control
Fan resistor pack
If you can't find what you're looking for in all that lot, try using the search function, top right. It can be a bit temperamental, but if you use a multiple word search and use the word "and" between each word, eg front and fan, you should find what you need.
Alternatively, get on the forum & join in
- Board index Using The Bongo Forum FAQs
- Search
-
- It is currently Tue May 28, 2024 3:30 pm
- All times are UTC+01:00
Fans & Heaters, Aircon, Climate Control.
Some topics come up again and again. Here you will find short cuts to frequently asked questions, mainly of a technical nature.
- missfixit70
- Supreme Being
- Posts: 12431
- Joined: Fri Jun 01, 2007 3:53 pm
- Location: weymouth
Fans & Heaters, Aircon, Climate Control.
Post by missfixit70 » Thu Dec 22, 2011 12:56 am
You can't polish a turd - but you can roll it in glitter.
Jump to
- Using The Bongo Forum
- ↳ Terms & Conditions
- ↳ Guidance
- ↳ FAQs
- ↳ How to Contact Us
- Bongo Fury
- ↳ Techie Stuff
- ↳ Bongo Bash 2024
- ↳ Bongo Chat
- ↳ Bongo Fuel & Performance Issues
- ↳ Fancy Meeting up & Bongo Trips
- ↳ Breaking Bongos
- ↳ Campervan Conversions in Bongos
- ↳ Stuff Wanted/ Free Stuff/Swaps
- ↳ Admin & Club Matters
- ↳ Bongo Camping Equipment
- ↳ Pimp My Bongo
- ↳ Was It You?
- ↳ Off Message
- ↳ Group Buys
- ↳ Bargains!
- ↳ Small Ads
- ↳ Bongoing with Children
- ↳ Insurance
- ↳ Campsites
- ↳ Bongo Furry!
- ↳ Going Abroad
- ↳ National Bongo Day 2020
- ↳ Bongo Bash 2023
- ↳ Bongo Bash 2022
- ↳ Bongo Bash 2021
- ↳ Bongo Bash 2019
- ↳ Bongo Bash 2018
- ↳ Bongo Bash 2016
- ↳ Bongo Bash 2017
- ↳ Bongo Bash 2015
- ↳ Bongo Bash 2014
- ↳ Bongo Bash 2013
- ↳ National Bongo Day Sunday 24/02/13
- ↳ Bongo Bash 2012
- ↳ Bulgaria 2011
- ↳ Bongo Bash 2011
- ↳ Bongo Bash 2010
- ↳ Bongo Bash 2009
- ↳ Poland 2008
- ↳ Bongo Bash 2008
- ↳ Bongo Bash 2007
- UK Groups
- ↳ Scotland
- ↳ North West
- ↳ Yorkshire & North East
- ↳ Wales/Cymru
- ↳ West Midlands
- ↳ East Midlands
- ↳ Eastern Counties
- ↳ Chilterns, Thames Valley & Cotswolds
- ↳ London, Kent & Sussex
- ↳ South Wessex
- ↳ Devon & Cornwall/Kernow
- ↳ Rest of the West
- International Section
- ↳ International
- ↳ Ireland